Laserfiche WebLink
JUNCTION BOX ON <br />BACK OF MODULE <br />PV WIRE <br />MIN. RADIUS FOR PV WIRE <br />600V OR LESS <br />8X WIRE Ø (56MM OR 2-1/8") <br />CONNECTOR PV WIRE <br />MIN. RADIUS 8X <br />CABLE DIAMETER <br />NOTES : <br />1. OBSERVE MIN. BENDING RADIUS REQUIREMENTS WHEN BUILDING AND <br />SECURING SOURCE CIRCUIT CONDUCTORS TO MODULES AND RACKING. <br />2. SEE MODULE SPEC SHEET OR CABLE SPECIFICATION FOR CABLE DIAMETER. <br />MODULE <br />PV WIRE <br />BUNDLED HOMERUN <br />CONDUCTORS <br />W/ ZIPTIES <br />MODULE <br />PV WIRE <br />A SCALE: <br />TYPICAL MODULE TO MODULE WIRE ROUTING <br />NTS <br />JUNCTION BOX ON <br />BACK OF MODULE <br />PV WIRE <br />PV MODULE FRAME <br />F SCALE: <br />WIRE CLIP-MODULE LEAD ATTACHMENT DETAIL <br />NTS <br />WIRE CLIP <br />P/N #111732 <br />12 Ø <br />SHORTER SIDE OF <br />PV MODULE FRAME <br />E SCALE: <br />TYPICAL EDGE CLIP DETAIL-1 <br />NTS <br />NOTES: <br />1. WIRE CLIP HOLDS 4 WIRES, 2 ON EACH SIDE <br />D SCALE: <br />TYPICAL EDGE CLIP DETAIL-2 <br />NTS <br />EDGE CLIP <br />P/N #111732 <br />BUNDLED HOMERUN <br />CONDUCTORS <br />W/ ZIPTIES <br />K SCALE: <br />MODULE CONNECTOR DETAILS <br />NTS <br />MALE <br />CONNECTOR <br />FEMALE <br />CONNECTOR <br />CONNECTORS MUST BE: <br />1. LOCKING TYPE, RATED TO 1000VDC. <br />2. MATED CONNECTORS MUST BE OF SAME MANUFACTURER <br />AND TYPE. <br />3. CRIMPED ONTO THE SOURCE CIRCUIT WIRE USING <br />PROCEDURE AND TOOLS RECOMMENDED BY MANUFACTURER. <br />4. SECURED SUCH THAT THEY ARE NOT SUBJECTED TO RAIN <br />OR DIRECT SUNLIGHT, SUCH AS WITHIN MODULE GAPS. <br />C SCALE: <br />PV WIRE BENDING REQUIREMENTS (GREATER THAN 600V) <br />NTS <br />SOLAR MODULE <br />SOLAR CELL OUTLINE <br />AS VIEWED FROM <br />UNDERSIDE OF MODULE <br />TO DAS <br />MODULE CELL TEMPERATURE <br />SENSOR TO BE AFFIXED DIRECTLY TO <br />THE CENTER OF A CELL IN THE <br />CENTER BACK OF THE MODULE. <br />FOLLOW MANUFACTURER PROVIDED <br />INSTALLATION INSTRUCTIONS FOR <br />SURFACE PENETRATION AND <br />SENSOR ATTACHMENT. <br />J SCALE: <br />MODULE CELL TEMPERATURE SENSOR/ IF REQUIRED <br />NTS <br />G SCALE: <br />CONDUIT GROUNDING <br />NTS <br />CONTINUOUS GROUND, <br />STRIP INSULATION AT LUG <br />ENCLOSURE WALL <br />GROUND BUSHING <br />WITH LAY-IN LUG <br />LOCK NUT <br />COMPRESSION <br />FITTING <br />CONDUIT <br />REPRESENTATIVE <br />CONDUCTORS <br />UNISTRUT P1000 OR <br />APPROVED EQUIV. <br />LENGTH TO SUIT <br />(4) 3 8" Ø X 2" EMBED STAINLESS STEEL HILTI KB TZ <br />OR APPROVED EQUIV. (CONCRETE OR FILLED <br />CMU), OR (4) 3 8" Ø X 2" EMBED. HILTI HY20 OR <br />APPROVED EQUIV. (HOLLOW MASONRY), OR (4) <br />1 4" Ø SCREWS (WOOD OR METAL STUD WALL) <br />H SCALE: <br />TYP. WALL MOUNTED CONDUIT <br />NTS <br />JUNCTION BOX <br />UNISTRUT P1000 <br />OR APPROVED <br />EQUIV. <br />CONDUIT <br />CONDUIT OFFSET <br />AS REQ'D <br />MOLDED RECYCLED RUBBER <br />SUPPORT BLOCK W/ INTEGRATED <br />STRUT CHANNEL, B-LINE <br />DURABLOCK OR APPROVED <br />EQUIV. <br />I SCALE: <br />JUNCTION BOX MOUNTING DETAIL <br />NTS <br />- <br />+ <br />1 STRING <br />NEGATIVE PV WIRE <br />CONNECTOR <br />POSITIVE PV WIRE <br />CONNECTOR <br />B SCALE: <br />TYPICAL MODULE TO MODULE WIRE ROUTING WITH RSD <br />NTS <br />NOTE: LOCATE CONNECTORS OUT OF <br />DIRECT UV/RAIN EXPOSURE <br />MODULE JUNCTION <br />BOX <br />NOTE: LOCATE CONNECTORS OUT OF <br />DIRECT UV/RAIN EXPOSURE <br />POSITIVE PV WIRE <br />CONNECTOR NEGATIVE PV WIRE <br />CONNECTOR <br />RAPID SHUT DOWN DEVICE <br />POSITIVE PV WIRE <br />CONNECTOR NEGATIVE PV WIRE <br />CONNECTOR <br />RAPID SHUT DOWN DEVICE <br />L SCALE: <br />RAPID SHUT DOWN DEVICE WIRE DETAILS <br />NTS <br />POSITIVE PV WIRE <br />CONNECTOR <br />NEGATIVE PV WIRE <br />CONNECTOR <br />SA <br />N <br />T <br />A <br /> <br />A <br />N <br />A <br /> <br />D <br />O <br />W <br />T <br />O <br />W <br />N <br /> <br />P <br />L <br />A <br />Z <br />A <br />40 <br />7 <br /> <br />E <br /> <br />1 <br />s <br />t <br /> <br />S <br />T <br />. <br />, <br /> <br />S <br />A <br />N <br />T <br />A <br /> <br />A <br />N <br />A <br />, <br /> <br />C <br />A <br /> <br /> <br />9 <br />2 <br />7 <br />0 <br />1 <br />JO <br />B <br /> <br />N <br />U <br />M <br />B <br />E <br />R <br />: <br />AP <br />N <br />: <br /> <br />3 <br />9 <br />8 <br />- <br />5 <br />1 <br />6 <br />- <br />1 <br />9 <br />SP <br />R <br />E <br />C <br />K <br /> <br />S <br />O <br />L <br />A <br />R <br /> <br />& <br /> <br />D <br />E <br />S <br />I <br />G <br />N <br />30 <br />0 <br />0 <br /> <br />F <br /> <br />D <br />A <br />N <br />V <br />I <br />L <br />L <br />E <br /> <br />B <br />L <br />V <br />D <br />. <br />, <br /> <br />S <br />U <br />I <br />T <br />E <br /> <br />4 <br />2 <br />2 <br />AL <br />A <br />M <br />O <br />, <br /> <br />C <br />A <br /> <br /> <br />9 <br />4 <br />5 <br />0 <br />7 <br />41 <br />9 <br /> <br />E <br /> <br />1 <br />s <br />t <br /> <br />S <br />T <br />. <br />, <br /> <br />S <br />A <br />N <br />T <br />A <br /> <br />A <br />N <br />A <br />, <br /> <br />C <br />A <br /> <br /> <br />9 <br />2 <br />7 <br />0 <br />1